Author Affiliations: Division of Infectious Diseases, University of Rochester School of Medicine and Dentistry and Rochester General Hospital, Rochester, New York (Dr Walsh); Departments of Infection Prevention (Ms Greene) and Cardiothoracic Surgery (Dr Kirshner), Rochester General Hospital; and Department of Cardiothoracic Surgery, The Cleveland Clinic, Cleveland, Ohio (Dr Kirshner).
Surgical site infections (SSIs) after cardiothoracic (CT) surgery carry significant morbidity and mortality as well as substantial monetary costs.1,2 Although the overall incidence of serious deep sternal or mediastinal wound infections is relatively low, ranging from 0.5% to 3%, prolonged hospitalization or readmission for extensive surgical debridement of the chest followed by lengthy antibiotic therapy is often required. Staphylococcus aureus is implicated in approximately half of these infections, with coagulase-negative staphylococci, gram-negative bacilli, and yeast organisms less frequently responsible.3,4 During the past 2 decades, the proportion of SSIs due to methicillin-resistant Staphylococcus aureus (MRSA) after cardiac surgery has steadily increased at many institutions.5 In contrast to many other pathogens, antibiotic therapy for MRSA is suboptimal and, even when combined with surgical debridement treatment, failure is not uncommon.6 Therefore, some institutions have developed strategies directed at preventing staphylococcal surgical wound infections, and specifically MRSA infections, after cardiac surgery.7- 20 Because it has generally been assumed that SSIs are caused by patients' endogenous flora, most control measures have focused on preoperative identification of MRSA carriers, with subsequent isolation, decolonization with intranasal mupirocin calcium ointment, and intravenous vancomycin for prophylaxis.8,10,17,19 The success of these efforts has been variable, although placebo- and historically controlled intervention studies have reported reductions of 37% to 90% in S aureus SSIs, including those due to MRSA.
Rochester General Hospital, Rochester, New York, is a community-based, 520-bed, medical-surgical hospital in which approximately 900 cardiac surgical procedures requiring median sternotomy are performed annually. Since the introduction of MRSA into the hospital in 1986, the incidence of MRSA SSIs has steadily increased. Despite persistent educational efforts with an emphasis on standard control measures that included weekly screening for MRSA colonization of patients in the CT intensive care unit and administration of vancomycin prophylaxis to known MRSA carriers, MRSA accounted for 54% of all SSIs in the 3 years from 2004 through 2006. In an attempt to reduce this rate, a novel comprehensive MRSA control program was instituted that has resulted in a nearly complete elimination of MRSA SSIs that has been sustained for 36 months.
Data from all patients who underwent cardiac surgery and required a median sternotomy incision from January 1, 2004, through January 31, 2010, are included in this report. Before this period, the cardiac surgical service used industrial engineering methods to standardize all components of preoperative, intraoperative, and postoperative care. These methods included skin cleansing and preoperative preparation with chlorhexidine alcohol and vigorous intraoperative and postoperative glucose control. Most patients were admitted electively or immediately after cardiac catheterization to a 24-bed CT surgical floor before surgery. A few patients were first admitted to general medical or cardiology floors before transfer to the CT service when the need for surgical intervention was identified. Elective admissions underwent preoperative evaluation, including nasal culture for MRSA, in a dedicated room on the CT floor 24 to 72 hours before admission. The same 3 surgeons performed all procedures with assistance from dedicated physician assistants and nursing staff. Whenever feasible, endoscopic saphenous vein harvest was performed, and most coronary artery bypass procedures included implantation of the left internal mammary artery. Other standardized components of the CT program included dedicated CT operating suits, nursing personnel, cardiac bypass pump teams, and anesthesiologists. Intravenous cefazolin, administered for 48 hours, was standard prophylaxis, with the exception that patients with a history of an immediate penicillin allergy received vancomycin. After surgery, all patients were transferred to a 13-bed CT intensive care unit for a minimum of 16 hours and then, when stable, to the CT surgical floor until hospital discharge, generally on postoperative day 4 or 5. Patients were seen within 2 weeks of discharge in the CT office for routine postoperative evaluation, including inspection of chest and leg incisions.
The same active and passing screening of all patients was used to identify infections throughout the period. A single infection prevention practitioner (L.G.) made daily rounds in the CT intensive care unit and on the CT unit to discuss postoperative cases or readmissions with the staff. After discharge, all surgical site cultures collected in the cardiac surgical office were reviewed, as were any cultures collected on readmission to Rochester General Hospital. Readmissions to other hospitals were also reviewed when possible. Classification of infections as superficial or deep and identification of the infecting organism were made by the infection prevention practitioner according to Centers for Disease Control and Prevention and National Healthcare Safety Network guidelines. Infections were attributed to the surgery if they occurred within 30 days or 1 year if the sternum or deep-organ space was involved. Infections resulting in hospitalization were reviewed with an infectious disease specialist and a CT surgeon.
A quality improvement program specifically designed to reduce MRSA infections on the CT service was initiated on February 1, 2007, when the following 5 measures were instituted: (1) at the outset of the program, all CT staff were screened for nasal carriage of MRSA and decolonized if identified; (2) all patients were screened for nasal MRSA carriage 1 to 3 days before surgery or as soon as possible after admission in the case of transfers from other institutions or in emergency cases (oxacillin-sensitive S aureus was not identified), followed by the addition of vancomycin prophylaxis for carriers; (3) mupirocin calcium nasal ointment was applied to the anterior nares of all patients regardless of colonization status beginning 1 day before surgery or on admission for emergency cases and continued for 5 days or until discharge if earlier than day 5; (4) all patients were rescreened for MRSA colonization on discharge from the hospital; and (5) on removal of chest and mediastinal tubes, the exit site was covered with a 4 × 4 sterile gauze pad coated with mupirocin. The intervention was reviewed by the Rochester General Hospital Clinical Investigation Committee and was considered exempt since it was a quality improvement program.
Nasal swabs were collected from the anterior nares of patients and cultured for MRSA on chromagar plates using standard procedures. Staphylococcus aureus was confirmed as coagulase positive. Mupirocin sensitivity testing using an E test strip (AB Biodisk, Solna, Sweden) was performed on 12 randomly selected hospital MRSA isolates that had been collected before the initiation of the program and on 10 isolates that had been collected in January 2010.
The SSI rates were compared using the χ2 test, and relative risk (RR) reduction and 95% confidence intervals (CIs) were calculated. P ≤ .05 was considered significant.
An average of 877 CT surgical cases were performed annually from 2004 through January 2010, with minor year-to-year variation (Table 1). A total of 2766 patients underwent surgery between January 1, 2004, and January 31, 2007 (baseline cohort), and a total of 2496 patients underwent surgery from February 1, 2007, through January 31, 2010 (intervention cohort). During the baseline period, 59 SSIs were identified, for an incidence of 2.1%. Of these, 32 (54%) were attributable to MRSA, yielding a 1.2% MRSA SSI rate during the 37-month baseline period.
Before the initiation of the MRSA intervention program, 98 CT surgical staff members, including the 3 surgeons, were screened for MRSA colonization. Two nurses were positive (2% colonization rate) and were decolonized with a 5-day course of intranasal mupirocin. Subsequent screening of staff was not done after the program began. After implementation of the program on February 1, 2007, all patients were assessed for nasal MRSA carriage before or just after admission. Fifty-six of the 2496 patients (2.2%) were colonized with MRSA on admission to the CT service. All but 3 of the colonized patients were negative on subsequent nasal culture before discharge (95% eradication rate). Most MRSA-colonized patients received intravenous vancomycin in addition to the standard cefazolin prophylaxis, with the exception of several patients who were taken to the operating room emergently and in whom MRSA screening cultures were not available until the following day. According to protocol, all patients, regardless of MRSA colonization status, received intranasal mupirocin for up to 5 days after surgery.
After implementation of the program, 2 of 2496 patients (0.08%) developed an MRSA SSI. This number represents a 93% reduction in MRSA SSIs from the baseline period (32/2766 vs 2/2496; RR, 0.069; 95% CI, 0.016-0.286; P < .001). If only patients who completed 6 months of postoperative follow-up are considered, the MRSA SSI rate is similar (2 MRSA infections per 2220 surgical procedures). In the first month after the program was initiated, one of the infections was identified in a patient who was not colonized on admission, and the other occurred in a patient who was transferred from another hospital for emergency bypass surgery at the beginning of the second year. The latter patient was colonized with MRSA on admission, and although intranasal mupirocin therapy was provided, vancomycin prophylaxis was not administered because screening results were unavailable until the day after surgery. Both infections involved the sternum and required extensive debridement, wire removal, and long-term intravenous antibiotic therapy.
Not surprisingly, the composite SSI rate was also significantly reduced during the intervention period, decreasing from 2.1% to 0.8% (59/2766 vs 20/2496; P < .001). This overall reduction in SSI was primarily attributable to the decrease in MRSA infections, since the decline in other bacterial and yeast infections was not statistically significant (27/2766 [1.0%] vs 18/2496 [0.7%]; P = .36) (Table 1). Although the incidence of oxacillin-sensitive S aureus infections also decreased by 56%, this decrease was not statistically significant (5/2766 vs 2/2496; P = .27). The decrease in MRSA SSIs was specific to the cardiac surgical service, as the overall incidence of MRSA SSIs after noncardiac surgery at Rochester General Hospital did not change during the study period (Table 2).
After institution of the control program, MRSA was transmitted to 9 of 2440 (0.4%) MRSA-negative patients (8 colonized and 1 infected). Baseline transmission data were not available because routine screening for MRSA was not performed before introduction of the intervention. However, the number likely had been considerably higher because 32 patients developed MRSA SSIs before the introduction of the program. Ten of 12 randomly selected MRSA isolates were sensitive to mupirocin before introduction of the program, and all 10 isolates from January 2010 were sensitive.
Staphylococcus aureus is consistently the most common pathogen associated with postoperative SSIs after CT surgery, and, in some institutions, as in ours, MRSA is more common than methicillin-sensitive isolates. Antibiotic therapy for serious MRSA infections is unsatisfactory, with high relapse rates, especially for isolates with vancomycin minimum inhibitory concentrations of 1.5 μg/mL or higher.6 At Rochester General Hospital, MRSA accounted for 54% of the SSIs on the CT service from January 2004 through January 2007, and standard measures emphasizing hand hygiene and isolation of known colonized or infected patients were ineffective at reducing postoperative MRSA infections. However, after introduction of the intervention, the incidence of MRSA SSIs declined immediately and dramatically. Including only patients in whom a 6-month postoperative follow-up period was complete, there was a greater than 90% reduction in MRSA SSIs that was sustained for at least 30 months. Using these data, the number needed to treat to prevent 1 postoperative MRSA wound infection was 93. Although other centers have also been able to reduce MRSA SSIs after CT surgery, the reported reductions have generally been lower and similar to the decline in rates of all S aureus SSIs. Our inability to detect a statistically significant decrease in oxacillin-sensitive S aureus infections is attributable to their relatively infrequent occurrence during the baseline period.
Since our program was initiated, only 2 cases of MRSA SSIs have been identified. It is possible that the first failure had a false-negative MRSA nasal screening culture result and thus would not have received vancomycin prophylaxis. It has been suggested that use of polymerase chain reaction assays to detect colonization might be more sensitive.10 The second failure, an emergency case that was not recognized as MRSA colonized until after surgery, did not receive vancomycin prophylaxis. These 2 failures suggest that vancomycin prophylaxis may be an important component to the intervention program for MRSA-colonized persons and that inoculation of the operative site may have occurred during surgery.
The design of our MRSA control program accounted for several variables that could be responsible for the development of MRSA infection. First, we assumed that not all MRSA SSIs develop as a result of contamination during the surgical procedure by endogenous flora of MRSA-colonized patients. We speculated, as have others, that for many patients bacteria reach the wound later in the hospital course, after a patient becomes colonized with MRSA in the postoperative period.8,11 In one study, 57% of the MRSA SSIs occurred in persons whose screening results were negative on admission.8 We also considered the possibility that mediastinal drain tubes might provide a conduit for pathogens to reach the sternum and mediastinal tissues, especially at the time of their removal. It is possible that MRSA, either in a newly colonized patient or from the hands of medical personnel, could enter the vacated chest tube track. Finally, the program was designed to circumvent the reality that hand hygiene of medical staff is sometimes suboptimal. To address each of these possibilities, we included several elements in the control program. To target vancomycin prophylaxis, rather than use it for all patients, it is necessary to screen all patients for MRSA colonization. We found that 2.2% of patients were colonized before surgery, similar to rates reported by others.8,11,21 This relatively low rate supports the concept that many wounds are seeded after the chest is closed in patients who are not originally colonized with MRSA. Assuming a similar preoperative MRSA colonization rate of 2.2% during the baseline period, this would mean that more than 50% of the patients would have had to develop an MRSA infection to account for the number of MRSA infections in the baseline period. Therefore, we believed that it was important not only to decolonize MRSA carriers but also to prevent postoperative colonization by treating all patients with intranasal mupirocin regardless of colonization status. This strategy appeared to be effective as only 9 of 2440 patients (0.4%) acquired MRSA colonization after the program was initiated. This rate is 5-fold lower than the rate reported from the United Kingdom, in which only MRSA-colonized patients were decolonized.11 It should be noted that in most studies mupirocin is administered only to patients with positive screening culture results or until cultures are finalized as negative if the therapy is initially begun in all patients. Our decision to add vancomycin to standard cefazolin prophylaxis for MRSA carriers, rather than to replace it, was in response to recent suggestions that β-lactam antibiotics provide better bactericidal activity than vancomycin for oxacillin-sensitive S aureus infections in addition to maintaining gram-negative antimicrobial coverage.12,22
A potential adverse consequence of our program is the emergence of mupirocin resistance among gram-positive organisms. It is important to stress that although we did not find emergence of mupirocin resistance, it must be noted that a very small number of isolates were tested. A more comprehensive ongoing monitoring program for such a development would be required, as resistance has been reported in Europe after widespread mupirocin use.13,20 Should mupirocin resistance become prevalent, it is likely that we will observe a rebound in MRSA SSIs on the CT service. Furthermore, we did not find any vancomycin-resistant enterococcal infections on the CT service or a change in hospital-wide MRSA sensitivity to vancomycin therapy during the intervention period.
One factor that was clearly beneficial for the success of this program was the long-standing use of industrial engineering methods for the design and operation of the CT surgical service. These engineering methods provided a rigorous consistency in patient flow and procedures, thus reducing the chance of random factors affecting patient outcome. Implementation of a regimented MRSA reduction intervention was relatively easy in such an environment and ensured a high level of compliance by the staff.
Several limitations of our findings should be recognized. Our analysis used data from a historical control group for comparison to data collected after an intervention was initiated rather than data from a double-blind, randomized, placebo-controlled study design. Although the latter provides a more rigorous assessment of the intervention, we believe that the use of the temporally proximal 3-year baseline period is reasonable since all other standardized procedures were in effect during the baseline period. During the 6 years encompassing the baseline and intervention periods, there were no major changes in surgical staff, technical procedures, or standard infection control measures. The only exception was the addition of the Premier Safety Surveillor (Cereplex Inc, Germantown, Maryland) Web-based infection control program to our standard surveillance methods during the intervention period. This program should have had the effect of detecting additional infections. Furthermore, the New York State public reporting law requires all hospitals to report SSIs to the facility in which the procedure was performed, and it also provides for validation of SSI data by on-site review. Nevertheless, it is possible that factors unrelated to the intervention program could have affected our observed MRSA SSI rates. For instance, a change in hospital-wide adherence to hand hygiene practices, a factor we did not rigorously measure, could have influenced MRSA SSI rates, or it is possible that the admission MRSA colonization rate during the baseline period was significantly higher than our measured rate during the intervention. However, hospital-wide rates of nosocomial MRSA SSIs on other surgical services did not change significantly during the intervention period, suggesting that other such effects were not operative. Another limitation is that we did not use a fastidious SSI detection method, such as routine 30-day postoperative telephone calls, to ascertain possible infectious complications but instead relied on physician- and staff-generated culture data and readmissions. Although our method for detecting infections may underestimate superficial wound infections, it is not likely to overlook serious deep wound infections. Finally, it should be noted that we cannot differentiate the beneficial effect of mupirocin therapy from vancomycin prophylaxis for MRSA carriers, as both measures were introduced simultaneously, and both have been independently associated with reductions in MRSA SSIs after cardiac surgery.12
In summary, we observed a sustained 93% reduction in MRSA SSIs after introduction of a program that included preoperative screening of all patients for MRSA carriage, with vancomycin prophylaxis for identified carriers; preoperative and postoperative intranasal mupirocin therapy for all patients regardless of colonization status; and application of mupirocin to chest tube sites on their removal.
Correspondence: Edward E. Walsh, MD, Infectious Diseases Unit, Rochester General Hospital, 1425 Portland Ave, Rochester, NY 14621 (Edward.firstname.lastname@example.org).
Accepted for Publication: July 8, 2010.
Published Online: September 13, 2010. 10.1001/archinternmed.2010.326
Author Contributions:Study concept and design: Greene, and Kirshner. Acquisition of data: Greene and Kirshner. Analysis and interpretation of data: Walsh and Greene. Drafting of the manuscript: Walsh and Greene. Critical revision of the manuscript for important intellectual content: Kirshner. Statistical analysis: Walsh. Administrative, technical, and material support: Greene and Kirshner. Study supervision: Walsh and Kirshner.
Financial Disclosure: None reported.
Previous Presentation: This study was presented in part at the Infectious Diseases Society of America Annual Meeting; October 30, 2009; Philadelphia, Pennsylvania.
Thank you for submitting a comment on this article. It will be reviewed by JAMA Internal Medicine editors. You will be notified when your comment has been published. Comments should not exceed 500 words of text and 10 references.
Do not submit personal medical questions or information that could identify a specific patient, questions about a particular case, or general inquiries to an author. Only content that has not been published, posted, or submitted elsewhere should be submitted. By submitting this Comment, you and any coauthors transfer copyright to the journal if your Comment is posted.
* = Required Field
Disclosure of Any Conflicts of Interest*
Indicate all relevant conflicts of interest of each author below, including all relevant financial interests, activities, and relationships within the past 3 years including, but not limited to, employment, affiliation, grants or funding, consultancies, honoraria or payment, speakers’ bureaus, stock ownership or options, expert testimony, royalties, donation of medical equipment, or patents planned, pending, or issued. If all authors have none, check "No potential conflicts or relevant financial interests" in the box below. Please also indicate any funding received in support of this work. The information will be posted with your response.
Some tools below are only available to our subscribers or users with an online account.
Download citation file:
Web of Science® Times Cited: 30
Customize your page view by dragging & repositioning the boxes below.
Enter your username and email address. We'll send you a link to reset your password.
Enter your username and email address. We'll send instructions on how to reset your password to the email address we have on record.
Athens and Shibboleth are access management services that provide single sign-on to protected resources. They replace the multiple user names and passwords necessary to access subscription-based content with a single user name and password that can be entered once per session. It operates independently of a user's location or IP address. If your institution uses Athens or Shibboleth authentication, please contact your site administrator to receive your user name and password.